| 713 | 15 | 295 |
| 下载次数 | 被引频次 | 阅读次数 |
由于我国黄河流域盐渍土地区含有高浓度SO42-,影响着在役混凝土的力学性能和耐久性，严重阻碍了再生混凝土(RAC)在工程中的应用。【目的】为快速研究黄河流域盐渍土地层含有高浓度SO42-并伴随地下水入渗和蒸发的侵蚀特点，【方法】以304不锈钢纤维再生混凝土(304SSFRAC)为研究对象，以再生混凝土(RAC)和普通钢纤维再生混凝土(PFRAC)作对比，采用5%Na_2SO4作为侵蚀溶液，开展硫酸盐侵蚀-干湿循环作用的室内耐久性快速试验，研究立方体抗压强度、相对动弹性模量和相对质量，并通过扫描电子显微镜(SEM)手段来表征304SSFRAC微观结构，最后采用Weibull函数建立耐久性退化模型来预测试件寿命。【结果】结果显示：在0～75次的循环周期内，试件立方体抗压强度、质量和动弹性模量有明显的增强，在75次循环后，试件表面出现微裂纹，各项性能指标开始下降；SEM微观观察到混凝土内部腐蚀产物包括钙矾石、石膏等晶体。通过Weibull函数建模可得到试件寿命，【结论】结果表明，试件寿命为304SSFRAC>PFRAC>RAC,体积掺量为2%的304SSFRAC在5%Na_2SO4干湿循环下最长使用寿命可达到499次左右。
Abstract：[Objective] Due to the saline soil area of the Yellow River Basin contains high concentrations of SO42-, which affects the mechanical properties and durability of in-service concrete, and seriously hinders the application of recycled concrete(RAC) in engineering. [Methods]Based on the erosion characteristics of high concentration of SO42- in saline soil and groundwater infiltration and evaporation in the Yellow River Basin, this paper takes 304 stainless steel fiber recycled concrete(304SSFRAC) as the research object, compares RAC with ordinary steel fiber recycled concrete(PFRAC), and uses 5% Na_2SO4 as the erosion solution to carry out the indoor durability accelerated test of sulfate erosion-wet-dry cycle. The compressive strength, relative dynamic elastic modulus and relative mass of the cube were studied, and the microstructure of 304SSFRAC was characterized by scanning electron microscope(SEM). Finally, the durability degradation model was established by Weibull function to predict the life of the specimen. [Results] The result show that the cubic compressive strength, mass and dynamic elastic modulus of the specimen are obviously enhanced in the cycle from 0 to 75 times, and after 75 cycles, the surface of the specimen appears microcracks, and all performance indexes begin to decline. Microscopically, the corrosion products in concrete include ettringite, gypsum and other crystals. [Conclusion] The result show that test piece life 304SSFRAC > PFRAC > RAC, and the maximum service life of 304SSFRAC with 2% volume content can reach about 499 times under 5% Na_2SO4 dry-wet cycle.
[1] 李晓光，李盛龙，陈冰野，等.硫酸盐-氯盐复合腐蚀作用下桩基础混凝土的配合比设计[J].水电能源科学，2013,31(10):113-116.LI Xiaoguang,LI Shenglong,CHEN Bingye,et al.Formula design of corrosion-resistant concrete under action of compound sulfate-chloride[J].Water Resources and Power,2013,31(10):113-116.
[2] 刘娟红，宋少民，高萌.水泥基材料在腐蚀环境中生成碳硫硅钙石的机理研究[J].建筑材料学报，2017,20(6):846-853.LIU Juanhong,SONG Shaomin,GAO Meng.Mechanism of formation of thaumasite in cement based materials in corrosive environment[J].Journal of Building Materials,2017,20(6):846-853.
[3] 陈伟，申培亮，李远.基于相对介电常数的新拌混凝土拌和物含水率测定方法与模拟[J].硅酸盐通报，2011,30(6):1233-1238.CHEN Wei,SHEN Peiliang,LI Yuan.Determination of water content of fresh concrete mixture based on relative dielectric constant and modeling[J].Bulletin of the Chinese Ceramic Society,2011,30(6):1233-1238.
[4] 路承功，乔宏霞，魏智强，等.盐渍土地区混凝土加速损伤劣化机理及基于Wiener过程可靠性分析[J].中国矿业大学学报，2021,50(2):265-272.LU Chenggong,QIAN Hongxia,WEI Zhiqiang,et al.Accelerated damage and deterioration mechanism of concrete in saline soil area and reliability analysis based on Wiener process[J].Journal of China University of Mining & Technology,2021,50(2):265-272.
[5] 刘娟红，马虹波，段品佳，等.硫酸盐干湿循环环境下超深井井壁混凝土抗腐蚀性能[J].材料导报，2021,35(12):12081-12086.LIU Juanhong,MA Hongbo,DUAN Pinjia,et al.Corrosion resistance of shaft wall concrete in ultra-deep wells under sulphate wet and dry cycling environment[J].Materials Reports,2021,35(12):12081-12086.
[6] WANG C,ZHANG Z,LIU Y,et al.Geometric and fractal analysis of dynamic cracking patterns subjected to wetting-drying cycles[J].Soil and Tillage Research,2017,170:1-13.
[7] LI Han,XU Shanhua,WANG Youde,et al.Deterioration of the bond behavior between CFRP and corroded steel in wet-dry cycling environment[J].Composite Structures,2021,272(15):114202.
[8] ZHAO Yasong,GAO Jianming,QI Bing,et al.Effect of flexural loading on degradation progress of recycled aggregate concrete subjected to sulfate attackand wetting-drying cycles[J].Journal of Southeast University (English Edition),2019,35(1):83-88.
[9] LI Y,SHI T F,LI Y Q,et al.Damage of magnesium potassium phosphate cement under dry and wet cycles and sulfate attack[J].Construction and Building Materials,2019,210:111-117.
[10] 莫延英，朱洪洲.一般干湿循环对混凝土力学性能及抗氯离子渗透性能的影响[J].水利水电技术，2020,51(7):171-176.MO Yanying,ZHU Hongzhou.Influence from normal dry-wet cycle on concrete mechanical performance and resistance to chloride ion penetration[J].Water Resources and Hydropower Engineering,2020,51(7):171-176.
[11] 肖建庄.再生混凝土[M].北京：中国建筑工业出版社，2008.XIAO Jianzhuang.Recycled Concrete [M].Beijing:China Architecture and Building Press,2008.
[12] 张少峰，齐红军.再生混凝土耐久性能研究进展[J].混凝土，2021(9):56-62.ZHANG Shaofeng,QI Hongjun.Durability research status of recycled aggregate concrete[J].Concrete,2021(9):56-62.
[13] 许金校，肖建庄，罗素蓉，等.纤维再生混凝土的研究进展与展望[J].工业建筑，2022,52(2):10-17.XU Jinxiao,XIAO Jianzhuang,LUO Surong,et al.Research progress and prospect of fiber-recycled concrete[J].Industrial Construction,2022,52(2):10-17.
[14] 叶艳霞，王宗彬，彭琼武，等.微细钢纤维高强轻骨料混凝土静力试验研究[J].建筑材料学报，2020,23(4):955-962.YE Yanxia,WANG Zongbin,PENG Qiongwu,et al.Static test of micro steel fiber high-strength lightweight aggregate concrete[J].Journal of Building Materials,2020,23(4):955-962.
[15] SB A,AFC B,EP C,et al.Damage evolution and probabilistic strain-lifetime assessment of plain and fiberreinforced concrete under compressive fatigue loading:Dual and integral phenomenological model[J].International Journal of Fatigue,2022,158(5):106739.
[16] 申鹏.国内304不锈钢热轧板材耐蚀性能的对比研究[D].兰州：兰州理工大学，2011.SHEN Peng.Comparative study on corrosion resistance of domestic 304 stainless steel hot-rolled sheet [D].Lanzhou:Lanzhou University of Technology,2011.
[17] 黄政宇，李旦.不锈钢纤维对超高性能混凝土的性能影响研究[J].铁道科学与工程学报，2019,16(2):376-383.HUANG Zhengyu,LI Dan.Study on the effect of stainless steel fiber on the performance of ultra-high performance concrete[J].Journal of Railway Science and Engineering,2019,16(2):376-383.
[18] LIKES L,MARKANDEYA A,HAIDER M M,et al.Recycled concrete and brick powders as supplements to Portland cement for more sustainable concrete[J].Journal of Cleaner Production,2022:132651.
[19] SOBHAN K,GONZALEZ L,REDDY D V.Durability of apavement foundation made from recycled aggregate concrete subjected to cyclic wet-dryexposure and fatigue loading[J].Materials & Structures,2016,49(6):2271-2284.
[20] 中华人民共和国住房与城乡建设部，中华人民共和国国家质量监督检验局.普通混凝土长期性能和耐久性能试验方法标准：GB/T 50082—2009[S].北京：中国建筑出版社，2009.Ministry of Housing and Urban-Rural Development,PRC,State Bureau of Quality Supervision and Inspection of the People′s Republic of China.Test Method Standard for Long-term Performance and Durability of Ordinary Concrete:GB/T 50082—2009 [S].Beijing:China Architecture and Architecture Press,2009.
[21] 王振波，孙鹏，刘伟康，等.硫酸盐侵蚀下ECC轴拉力学性能与微观结构[J].华中科技大学学报(自然科学版),2021,49(7):31-36.WANG Zhenbo,SUN Peng,LIU Weikang,et al.Tensile properties and microstructure of ECC under sulfate attack [J].Journal of Huazhong University of Science and Technology (Natural Science Edition),2021,49(7):31-36.
[22] 申鹏.国内304不锈钢热轧板材耐蚀性能的对比研究[D].兰州：兰州理工大学，2011.SHEN Peng.Comparative study on corrosion resistance of domestic 304 stainless steel hot-rolled sheet [D].Lanzhou:Lanzhou University of Technology,2011.
[23] 冯琦，王宇斌.粉煤灰再生混凝土在干湿循环-抗硫酸盐侵蚀耦合条件下的耐久性研究[J].混凝土，2021(5):42-45.FENG Qi,WANG Yubin.Study on the durability of recycled fly ash concrete under the coupling condition of dry wet cycle and sulfate resistance[J].Concrete,2021(5):42-45.
基本信息:
DOI：10.13928/j.cnki.wrahe.2023.04.017
中图分类号:TU528.572
引用信息:
[1]钟楚珩,施佳楠,周金枝.硫酸盐侵蚀-干湿循环下不锈钢纤维再生混凝土耐久性分析[J],2023,54(04):187-196.DOI:10.13928/j.cnki.wrahe.2023.04.017.
基金信息:
桥梁结构健康与安全国家重点实验室(BHSKL19-04-KF);; 湖北省教研项目(2017314);; 湖北工业大学博士启动基金(BSQD2020051);; 国家自然科学基金青年科学基金项目(52108315)