低温暴露养护条件下混凝土强度增长规律研究Research on the growth law of concrete strength under low temperature exposure curing conditions
方仁义,于蕾,范波,王学光
摘要(Abstract)：
为研究现浇混凝土在低温暴露条件下养护时的早期强度增长规律，试验设置5℃、0℃、-5℃三个低温环境，凝结期以贯入阻力为指标，硬化期以抗压强度为指标，研究了混凝土从浇注到90 d不同龄期的强度变化规律；结果表明：完全暴露在负温环境下不做任何养护的混凝土并未停止凝结硬化；负温暴露养护会严重延长C30混凝土的初凝时间，约为0℃时的5倍，对C50混凝土影响不大；负温暴露养护下C30混凝土硬化后的强度明显偏低，90 d强度仍达不到设计强度，对C50混凝土影响不大；负温暴露养护下，混凝土的终凝时间及强度增长速度与海拔和当地最冷月平均温度呈正相关关系，C30混凝土在低温暴露养护下的28 d比3d抗压强度增幅较大，比值达6.17,C50混凝土强度发展较稳定比值最大1.86;建议久马高速在建设过程中从10月至次年4月浇注混凝土后即刻对C30等低标号混凝土构件与大地连接部位进行密封热养护，避免低标号混凝土凝结前在负温下暴露，对于C50混凝土若不得已暴露在低温环境，需延长拆模时间。
关键词(KeyWords)： 低温;养护;混凝土;强度;规律
基金项目(Foundation): 四川省交通运输科技计划项目(2019-ZL-18)
作者(Author): 方仁义,于蕾,范波,王学光
DOI: 10.13928/j.cnki.wrahe.2024.S2.110
参考文献(References)：
- [1] 中华人民共和国住房和城乡建设部.混凝土结构耐久性设计标准：GB/T 50476—2019[S].北京：中国建筑工业出版社.2019.
- [2] 李奋，杨永鹏，刘贺业，等.负温条件下混凝土抗压强度发展规律研究[J].铁道建筑，2016(2):162-165.
- [3] 文超，刘晓铮，尚静媛.冬期施工条件下混凝土实体抗压强度的发展规律研究[J].工程质量，2016,34(1):93-96.
- [4] 田悦.低温条件下外掺料对混凝土强度发展的影响[J].工程建设与设计，2015(1):59-61.
- [5] 林梦凯，王起才，李海莲，等.持续低温环境下混凝土水化程度及孔结构变化对强度影响试验研究[J].混凝土，2015(12):4-7.
- [6] 徐志飞，袁文韬，张远，等.高低温交变环境对混凝土性能影响研究[J].新型建筑材料，2022(6):112-115.
- [7] 王媛，毛顺伟，罗武，等.滇东北低温环境对混凝土性能的影响[J].低温建筑技术，2015(8):18-20.
- [8] 杨永.低温环境下碱矿渣胶结材水化行为与早期强度研究[D].重庆：重庆大学，2020.
- [9] 郭海贞，张戎令，王起才，等.-3 ℃养护条件下矿物掺合料对混凝土强度和孔隙结构的影响研究[J].混凝土，2020(4):103-109.
- [10] TORRENTI J M,BENBOUDJEMA F.Mechanical threshold of cementitious materials at early age[J].Materials and Structures,2005(38):299-304.
- [11] ZHANG H,AI J H,REN Q,et al.Understanding the strength evolution of alkali-activated slag pastes cured at subzero temperature[J].Cement and Concrete Composites,2023(138):104993.
- [12] AHMED Y,MOHAMED T.Cold weather concreting:provisions of codes and research advances[J].2024,177(5):1747-6518.
- [13] LIU S,HAO H,HAO Y,et al.Mechanical properties of alkali-activated concrete exposed to cryogenic temperature[J].Cement and Concrete Composites,2023,141 :105112.
- [14] WANG Y Z,YANG W C,ZHANG A,et al.Investigating icing behavior in cementitious material during freeze-thaw using low-temperature low-field NMR[J].Cement and Concrete Research,2024,175:107378.
- [15] ZHANG R L,LONG Z F,LONG G C,et al.Investigating concrete performance:Compressive strength and pore-structure evolution in simulated permafrost Conditions of the Qinghai–Tibet Plateau Zone[J].Journal of Materials in Civil Engineering,2024,36(5):04024063.
- [16] CHEN X,FENG Y R,HUANG X,et al.Microstructures and properties of concrete surfaces under different exposure conditions in complex natural environments of high-altitude regions[J].Journal of Building Engineering,2023,72:106663.
- [17] XU W B,ZHANG Y L,LIU B.Influence of silica fume and low curing temperature on mechanical property of cemented paste backfill[J].Construction and Building Materials,2020,254:119305.
- [18] XU W B,ZHANG Y L,ZUO Z H,et al.Time-dependent rheological and mechanical properties of silica fume modified cemented tailings backfill in low temperature environment[J].Cement and Concrete Composites,2020,114:103804.
- [19] DAI J P,WANG Q C,LOU X Y.Solution calorimetry to assess effects of water-cement ratio and low temperature on hydration heat of cement[J].Construction and Building Materials,2021,269:121222.
- [20] LIU Z Y,YU T L,YAN N,et al.The role of double-cylinder insulation technology in ensuringthe quality of bored pile concrete under negative temperature condition[J].Jordan Journal of Mechanical and Industrial Engineering,2021,15:51-58.
- [21] WANG M X,ZONG Q,WANG H B.An experimental study on mechanical properties and fracture characteristics of saturated concrete under coupling effect of low temperature and dynamic load[J].Geofluids,2022,1:5201061.